View Single Post
  #7  
Old 08-14-2012, 10:45 AM
malavalley malavalley is offline
Dodge Ram Forum Newcomer
 
Join Date: Aug 2012
Location: W. MASS
Age: 34
Posts: 4
Gender: Male
Vehicle: 2011 Ram 1500 Big Horn Quad
Trim Level: Big Horn
Color: Silver
Engine: 2009-20?? 345ci (5.7L) Hemi V8 390hp 407lb/ft
Rep Power: 0
Rep:10
malavalley is on a distinguished road
Default

My dash rattled in my 2011. You could alleviate the rattle by ever so slightly pressing down on the dashboard itself above the radio. After 3 failed attempts by the dealer to repair it I pulled the radio and bezel out to investigate. What I found was the union to the defrost duct was too tight and would rattle with movement(there is a foam seal for reference that hides the joint). Since they glued the duct to the dash board, any time the dash board vibrates it cause the two ends of the duct to rattle together and resonate through the dash. I ended up removing the foam seal and carefully trimmed the ducts with a razor. I resealed them with some gorilla duct tape...no more rattles. I also did my fathers 2009 sport so probably problem over series of years. Hope that helps.
Reply With Quote